Translate to: German | French
Spanish | Portugese | Italian
| Date: | Mon, 07 Feb 2000 22:43:07 |
| Subject: | Re: tomos clutch |
| From: | StevesMoped@aol.com |
| Reply to author Post followup (list members only) Back to index Subscribe to the mailing list Unsubscribe from the list |
Dear Ryan :
In regard to you Tomos Mopeds transmission problem..............
The clutch shoes on your 1981 Tomos moped are replaceable and you do not need
a puller to remove them. There are 3 shoes per clutch, a total of 6 shoes.
To remove the nut holding the clutch hub it is best to use an air impact
wrench and the nut will come right off. Clean the entire transmission and
cases. Flush out the transmission case including the motor cavity with
solvent. Replace all 6 clutch shoes. On the gear shaft that you said is
wobbling that is normal because it is supported by the bearings in the
transmission case. You can actually take the whole gear shaft out by hand.
There is a small spring located behind the gears that looks like a C made of
wire. This should also be replaced along with the transmission gasket. Make
sure that all of the bearings rotate freely and without play. All of the
teeth on the gears gears uniform. The clutch drum is smooth. There are a lot
of things to look for and experience helps when working on a 2 speed
automatic transmission. Call us if you need any help and we stock every
single part of the Tomos transmission.
Best regards:
Adam, Justin and Drew Parts
Department
Steve's Moped & Bicycle World Inc.
40 Park Avenue Dumont NJ 07628
Main Mega Store: ph(201)384-7777 fAX(201)384-7831
Dumont Store Hours: Mon. and Fri. 10:30am-7pm Tues. & Thurs. Till 8pm
Sat. 9:30 to 5pm E-MAIL MOPEDMOPED@AOL.COM
WEB ADDRESS WWW: STEVESMOPED.COM
.*****************************************************************************
**********
Smaller Satalite Store:
Also Steve's Moped World 2427 Bridge Ave. Point Plesant NJ 08742 (732)295-4200
Call Ponint Pleasant for hours. (closed mondays and open sundays)
| Reply to author Post followup (list members only) Back to index Subscribe to the mailing list Unsubscribe from the list |
